XPS SERIES MANUAL PUSH STACKER
An ergonomic alternative to manual lifting, intermediate-duty stacking and pallet positioning applications. Choose models with 1,500 lb to 3,000 lb capacities with lift heights up to 118" (2,997mm) to tackle your materials handling applications.
CAPACITIES	LIFT HEIGHTS
• 1,500 lb at 24” load center • 2,200 lb at 24” load center • 3,000 lb at 24” load center	• 63 inches • 98 inches • 118 inches
OPERATION/CONTROLS • Up/Down lever control mounted on dash • Operator protection screen • Excellent forward visibility and pallet handling • Dual push handles mounted at comfort height level on mast • Ergonomic spring-loaded steering handle with comfort grip
POWER/HYDRAULIC • 12 Volt powered lift system, manually propelled • 12 Volt minimum maintenance deep cycle battery and built-in    charger, for 110/1/60 plug-in • Flow control valve at base of cylinder to regulate lowering speed • On/Off key switch • Battery gauge
FORKS/CHASSIS • 42” long forged forks, 31” OD adjustment on pin style carriage • Straddle legs adjust to three (3) positions for varying pallet sizes • Channel mast fitted with heavy-duty roller bearings and dual lift chains • Easy access battery compartment panel • Foot brake provides extra stability during load lifting/lowering
WHEELS • 3” diameter polyurethane load wheels • 7” diameter nylon pivot steer wheels
OPTIONAL EQUIPMENT • Optional model heights 130" and 150" (see bottom of page for WPS Series)
		Adjustable Straddles	Easy Access Controls

SPECIFICATIONS
		Be A Safe Operator.
		• Do not operate this truck unless you have been trained and    authorized to do so. • Do not operate this truck until you have checked its condition.    Give special attention to tires, battery, controls, lifting systems    (including switches), brakes, steering mechanism, guards and    safety devices. • Report the need for truck repairs to your supervisor promptly.    Do not operate the truck. Neglect may cause a minor repair to    become a major service problem or cause the truck to become    unsafe. • The manual push stacker is intended for use on level surfaces only. • Do not exceed the rated capacity of the vehicle as marked on the    nameplate. Do not lift with the fork tips or one fork only, and be    sure load is centered and the 24”(610mm) load center is not    exceeded. • Do not handle unstable or loosely stacked loads. Use special care    when handling long, high or wide loads, to avoid tipping, loss of    load, or striking bystanders. • Always look in direction of travel. Keep a clear view and when    load obstructs visibility, travel with load trailing (except when    climbing ramps). • Watch swing clearance when turning near walls, racks, pillars or    other obstacles. • Start, stop, change direction, travel and brake smoothly. Slow    down for turns and on uneven or slippery surfaces that could    cause truck to slide or tip. Be aware that the truck behaves    differently without a load than with a load. • Observe applicable traffic regulations and yield right of way to    pedestrians. Slow down and sound horn at all aisle intersections    and where vision is obstructed. Do not ride on truck unless    equipped with a rider platform. • Do not carry passengers.

		Optional model heights 130" and 150"
		WPS Series
		The WPS Series Power Lift Stacker is an economical easy to use solution for intermediate duty load positioning and stacking operations. Choose models with 2,200 lb capacities with lift heights up to 150" (3,810mm) to tackle your materials handling application
		• Manually propelled with push button lift/lower control mounted on dash. • Adjustable straddles - 36" to 50" ID. • Straddle adjustment jack supports • 42" long adjustable forged forks • 12 volt system c/w minimum maintenance deep cycle battery • Digital battery discharge indicator • On/Off key switch • Emergency power disconnect stop button • Operator protector screen • Ergonomic push/pull handles comes with spring pivot steering handle • Phenolic load rollers and easy steer swivel casters • Foot pedal parking brake

Back to Product Page